Influence of the inner tilt angle on downwash airflow field of multi-rotor UAV based on wireless wind speed acquisition system

Ling Wang, Qihang Hou, Junpeng Wang, Zhiwei Wang, Shumao Wang

Abstract


The downwash airflow field is an important factor influencing the spraying performance of plant protection UAV, and the structural design of rotors directly affects the characteristics of the downwash airflow field. Therefore, in this study, three-dimensional models of a six-rotor UAV with various inner tilt angles were established to simulate and analyze the influence of the inner tilt angle on the downwash airflow field based on the Reynolds average NS equation, RNG k-ε turbulence model, etc.. On this basis, a wireless wind speed acquisition system using the TCP server was developed to carry out the test through the marked points with real-time detection. The simulation results show that, the variation of inner tilt angles of the six-rotor UAV did not cause significant difference in the time dimension of the downwash airflow field, and with the change of the inner tilt angle from 0° to 8°, the distribution of downwash airflow field tended to obliquely shrink towards the central axis direction, and the amplitude of linear attenuation of airflow speed was also increased, which the difference of attenuation amplitude was 1 m/s. Besides, under the different inner tilt angle, the airflow velocity in “lead in area” was significantly greater than that in the “lead out area”, and the difference of air velocity distribution in space would affect the uniformity of droplet deposition. Through the calibration test, the measurement accuracy error of the developed system was lower than 0.3 m/s, and the adjusted R2 of the calibration fitting equation was higher than 0.99. The test and simulation values at test points from 0.2-2.3 m below the rotors exhibit the same variation trend, and the average relative error at the height of 1.1-2.3 m below the rotors and 0.2-0.8 m near the ground was within 10% and 20%, respectively. The simulation and test results were highly reliable, which could provide basis and reference for the design and optimization of plant protection drones.
Keywords: plant protection UAV, downwash airflow field, inner tilt angle, numerical simulation, wind speed acquisition
DOI: 10.25165/j.ijabe.20211406.6477

Citation: Wang L, Hou Q, Wang J P, Wang Z W, Wang S M. Influence of inner tilt angle on downwash airflow field of multi-rotor UAV based on wireless wind speed acquisition system. Int J Agric & Biol Eng, 2021; 14(6): 19–26.

Keywords


plant protection UAV, downwash airflow field, inner tilt angle, numerical simulation, wind speed acquisition

Full Text:

PDF

References


Wang L, Lan Y B, Hoffmann W C, Bradley K F, Chen D, Wang S M. Design of variable spraying system and influencing factors on droplets deposition of small UAV. Transactions of the CSAM, 2016; 47(1): 15–22. (in Chinese)

Li J Y, Shi Y Y, Lan Y B, Guo S. Vertical distribution and vortex structure of rotor wind field under the influence of rice canopy. Computers and Electronics in Agriculture, 2019; 159: 140–146.

Chen S D, Lan Y B, Bradley K F, Li J Y, Liu A M, Mao Y D. Effect of wind field below rotor on distribution of aerial spraying droplet deposition by using multi-rotor UAV. Transactions of the CSAM, 2017; 48(8): 105–113.

Angelis E L D. Stability analysis of a multirotor vehicle hovering condition. Aerospace Science and Technology, 2018; 72: 248–255.

Wang J X, Wang Z, Zhang H, Liu S X, Xing L L, Li Y Y, et al. Optimal experiment of variable spraying parameters for UAV with low volume and low altitude. Jiangsu Agricultural Sciences, 2018; 46(17): 215–219. (in Chinese)

Fritz B K. Meteorological effects on deposition and drift of aerially applied sprays. Trans ASABE, 2006; 49(5): 1295–1301.

Zhu H, Lan Y B, Wu W F, Hoffmann W C, Huang Y B, Xue X Y, et al. Development of a PWM precision spraying controller for unmanned aerial vehicles. Journal of Bionic Engineering, 2010; 7(3): 276–283.

Lan Y B, Thomson S J, Huang Y B, Hoffmann W C, Zhang H H. Current status and future directions of precision aerial application for site-specific crop management in the USA. Computers and Electronics in Agriculture, 2010; 74(1): 34–38.

Lian Q. Study on the variation of downwash and the installation position of nozzles in a six-rotor plant protection drone. Heilongjiang: Heilongjiang Bayi Agricultural University, 2019. (in Chinese)

Technical parameters of T30 plant protection UAV. http://www.dji.com/cn/t30. 2020.11.

Agricultual UAV of V40. https://www.xa.com/v40-2021. 2021.4.

Xu Z. SMC based wind disturbance rejection for quad-rotor UAVs. Electronics Optics & Control, 2017; 24(1): 67–71.

Balaji S, Prabhagaran P, Vijayanandh R, Kumar MS, Kumar RR. Comparative computational analysis on high stable hexacopter for long range applications. Lecture Notes in Civil Engineering, 2020; pp. 369–391.

Wang P, Hu L, Zhou Z Y, Yang W S, Liu A M, Luo X W, et a1. Wind field measurement for supplementary pollination in hybrid rice breeding using unmanned gasoline engine single-rotor helicopter. Transactions of the CSAE, 2013; 29(3): 54–61. (in Chinese).

Wu Y L, Qi L J, Zhang H, Musiu E, Yang Z P, Wang P. Design of uav downwash airflow field detection system based on strain effect principle. Sensors, 2019; 19: 2630.

Tang Q, Zhang R R, Ding C, Chen L P, Xu M, Xu G, et al. Application of ultrasonic anemometer array to field measurements of the downwash flow of an agricultural unmanned helicopter. Transactions of the ASABE 2019; 62(5): 1219–1230.

Li J Y., Lan Y B, Wang J W, Chen S D, Huang C, Liu Q, et al. Distribution law of rice pollen in the wind field of small UAV. Int J Agric & Biol Eng, 2017; 10(4): 32–40.

Kompenhans J, Raffel M, Vogt A, Fischer M, Bretthauer B, Vollmers H, et al. Investigation of unsteady flow fields in wind tunnels by means of particle image velocimetry. Part of the ERCOFTAC Series book series. 1994

Yang F B, Xue X Y, Zhang L, Sun Z. Numerical simulation and experimental verification on downwash air flow of six-rotor agricultural unmanned aerial vehicle in hover. Int J Agric & Biol Eng, 2017; 10(4): 21–53.

Yang S H, Tang Q, Zheng Y J, Liu X X, Chen J, Li X L. Model migration for CFD and verification of a six-rotor UAV downwash. Int J Agric & Biol Eng, 2020; 13(4): 10–18.

Khalilzadeh A, Ge H, Ng H D. Effect of turbulence modeling schemes on wind-driven rain deposition on a mid-rise building: CFD modeling and validation. Journal of Wind Engineering and Industrial Aerodynamics, 2019; 184: 362–377.

Guo Q W, Zhu Y Z, Tang Y, Hou C J. CFD simulation and experimental verification of the spatial and temporal distributions of the downwash airflow of a quad-rotor agricultural UAV in hover. Computers and Electronics in Agriculture, 2020; 172(4): 105343.

Yang F, Xue X, Cai C, Zhou Q Q. Effect of down wash airflow in hover on droplet motion law for multi-rotor unmanned plant protection machine. Transactions of the CSAE, 2018; 34(2): 64–73. (in Chinese)

Liu H, Chang J L, Hou Z F, Chen Z, Xuan C Z, Shang X B. Investigation on near-surface wireless wind speed profiler based on thermistors. Transactions of the CSAM, 2017; 48(12): 68–77. (in Chinese)




Copyright (c) 2021 International Journal of Agricultural and Biological Engineering

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.

2023-2026 Copyright IJABE Editing and Publishing Office